Description
OBD-II Trouble Code Description for P0216 Chevrolet
Injector/Injection Timing Control Circuit
What does this mean?
OBD2 Code P0216 Chevrolet definition:
Basically this means the diesel fuel injection pump has a timing failure. This could be that the injection pump timing needs adjusted OR the failure is internal to the injection pump and therefore non-adjustable. NOTE: If your vehicle is a Dodge Ram with Cummins engine then be aware that fuel delivery problems frequently cause this code. Prolonged fuel delivery problems can cause injection pump failure!
Symptoms
Possible sumptoms of OBD code P0216 Chevrolet
Symptoms of a P0216 Chevrolet DTC may include: P0216 Chevrolet DTC Low power Crank, but no start Hard start Displays an intermittent stumble or miss Engine may start and then stall Engine may appear to drive fine but surge at idle
Causes
Possible causes of OBD code P0216 Chevrolet
The most frequent cause of this code is a bad injection pump due to poor fuel delivery. Fuel delivery problems could be: A plugged diesel fuel filter An in-tank blockage Air in the fuel due to a cracked in-tank fuel ine above the fuel level Bad transfer (lift) pump Injection pump out of time
Possible Solutions
First, simply check if your injection pump timing is adjustable. If so, check the timing and adjust if necessary. If you think that you may have a fuel delivery problem, then check the lift pump operation. On Dodge Ram with the Cummins engine, the lift pump should produce about 45 oz of diesel in 25 seconds of operation. This can be performed by disconnecting the fuel hose from the injection pump and pumping the fuel into an approved container. Bump the engine over but do not start it. Then the lift pump will operate for 25 seconds. If the fuel is aerated, then check/repair fuel line and recheck. With the fuel hose connected the fuel pressure should be 10psi. If the fuel delivery tests fail, replace the diesel fuel filter and recheck. If it still fails then verify there are no restrictions in the fuel tank Then replace the lift (transfer) pump. IT SHOULD BE NOTED that if this code surfaced after a routine fuel filter replacement or if you have any of the above symptoms after routine fuel filter replacement, then suspect the fuel transfer pump. This occurs because even a weak transfer pump can still provide enough fuel for the engine to run. But when the fuel system’s prime is lost due to fuel filter replacement, it may not restart again without fixing the fuel delivery problem. If you found your injection pump to be bad, the lift pump should be checked for operation to protect the new injection pump. This is because weak or low output from lift pump are common cause of injection pump failure. There are some aftermarket kits that can be purchased to warn the operator when the fuel pressure/volume drops to level that could damage the injection pump.
The OBD2 Code Information Be Applicable For Chevrolet
2013 Chevrolet Traverse2013 Chevrolet Trailblazer2013 Chevrolet Spark2013 Chevrolet Sonic RS2013 Chevrolet Onix2013 Chevrolet Malibu ECO2013 Chevrolet Malibu2013 Chevrolet Cruze Station Wagon2013 Chevrolet Corvette 427 Convertible2013 Chevrolet Camaro ZL1 Convertible2013 Chevrolet Camaro Hot Wheels Edition2013 Chevrolet Camaro 1LE2012 Chevrolet Tru 140S Concept2012 Chevrolet Sonic Sedan2012 Chevrolet Sonic2012 Chevrolet Silverado2012 Chevrolet Orlando2012 Chevrolet Cruze Hatchback2012 Chevrolet Corvette Z06 Centennial Edition2012 Chevrolet Corvette Daytona Racecar2012 Chevrolet Colorado2012 Chevrolet Code 130R Concept2012 Chevrolet Captiva2012 Chevrolet Camaro ZL12012 Chevrolet Camaro EU Version2012 Chevrolet Camaro Convertible EU Version2012 Chevrolet Camaro COPO Convertible2012 Chevrolet Camaro COPO2012 Chevrolet Camaro 67 Hot Wheels Concept2012 Chevrolet Camaro 45th Anniversary Edition2012 Chevrolet Aveo Sedan2011 Chevrolet Volt2011 Chevrolet TrailBlazer Concept2011 Chevrolet Silverado HD2011 Chevrolet Sail2011 Chevrolet Miray Concept2011 Chevrolet Cruze2011 Chevrolet Corvette Z06 Carbon Limited Edition2011 Chevrolet Colorado Rally Concept2011 Chevrolet Colorado Concept2011 Chevrolet Caprice Police Patrol Vehicle2011 Chevrolet Camaro SS Convertible Indy 500 Pace Car2011 Chevrolet Camaro Convertible Neiman Marcus2011 Chevrolet Camaro Convertible2011 Chevrolet Aveo2010 Chevrolet Volt MPV5 Concept2010 Chevrolet Spark2010 Chevrolet Equinox2010 Chevrolet Corvette Z06X Concept2010 Chevrolet Corvette Grand Sport2010 Chevrolet Camaro Transformers2010 Chevrolet Camaro SS Indy 500 Pace Car2010 Chevrolet Camaro SSX Concept2010 Chevrolet Camaro SS2010 Chevrolet Camaro Red Flash Concept2010 Chevrolet Camaro2010 Chevrolet Aveo RS Concept2010 Chevrolet Agile2009 Chevrolet Traverse2009 Chevrolet Stingray Concept2009 Chevrolet Cruze WTCC2009 Chevrolet Cruze2009 Chevrolet Corvette ZR12009 Chevrolet Corvette GT12009 Chevrolet Aveo52008 Chevrolet Orlando Concept2008 Chevrolet Matiz2008 Chevrolet Malibu LTZ2008 Chevrolet Malibu LT2008 Chevrolet Lumina SS2008 Chevrolet HHR SS2008 Chevrolet GPiX Concept2008 Chevrolet Equinox Sport2008 Chevrolet Corvette2008 Chevrolet Captiva Sport2008 Chevrolet Camaro LS7 Concept2008 Chevrolet Camaro GS Racecar Concept2008 Chevrolet Camaro Black Concept2008 Chevrolet Aveo2007 Chevrolet Volt Concept2007 Chevrolet Trax Concept2007 Chevrolet Tahoe2007 Chevrolet Suburban LTZ2007 Chevrolet Silverado Regular Cab2007 Chevrolet Silverado Extended Cab2007 Chevrolet Silverado Crew Cab2007 Chevrolet Silverado 3500 HD LTZ Crew Cab2007 Chevrolet Silverado 2500 HD LTZ Extended Cab2007 Chevrolet Jay Lenos Corvette C6RS E852007 Chevrolet HHR Panel2007 Chevrolet Groove Concept2007 Chevrolet Camaro Convertible Concept2007 Chevrolet Beat Concept2007 Chevrolet Avalanche LTZ2007 Chevrolet 34 Coupe E85 Concept2006 Chevrolet WTCC Ultra Concept2006 Chevrolet TrailBlazer SS2006 Chevrolet Silverado Z71 Extended Cab2006 Chevrolet Silverado Intimidator SS2006 Chevrolet Silverado Hydrogen Military Vehicle2006 Chevrolet Sequel Concept2006 Chevrolet Nubira Station Wagon WTCC R2006 Chevrolet Monte Carlo SS2006 Chevrolet Malibu SS2006 Chevrolet Malibu Maxx SS2006 Chevrolet Kodiak C45002006 Chevrolet Impala SS2006 Chevrolet Impala2006 Chevrolet HHR LT2006 Chevrolet Epica2006 Chevrolet Corvette Z06 Daytona 500 Pace Car2006 Chevrolet Corvette Z062006 Chevrolet Cobalt SS2006 Chevrolet Cobalt LT2006 Chevrolet Celta2006 Chevrolet Captiva2006 Chevrolet Camaro Concept2006 Chevrolet Aveo Sedan2005 Chevrolet West Coast Customs HHR2005 Chevrolet Uplander2005 Chevrolet Silverado Hybrid2005 Chevrolet Kodiak2005 Chevrolet Equinox2005 Chevrolet Corvette C6R Race Car2005 Chevrolet Corvette C62005 Chevrolet Corvette2005 Chevrolet Cobalt Sedan2005 Chevrolet Cobalt SS Supercharged Coupe2005 Chevrolet Cobalt SS2005 Chevrolet Cobalt2005 Chevrolet Cavalier Xtreme2005 Chevrolet Astra GSi 2.0 16V2005 Chevrolet Astra 2.0 Flexpower Elite2005 Chevrolet Astra 2.0 Flexpower Elegance2005 Chevrolet Astra 2.0 Flexpower Comfort2004 Chevrolet Tracker Turbo2004 Chevrolet Silverado2004 Chevrolet SOCAL SSR Bonneville Salt Flats2004 Chevrolet S3X Concept2004 Chevrolet Nomad Concept2004 Chevrolet Monte Carlo SS2004 Chevrolet Matiz M3X Concept2004 Chevrolet Malibu Maxx2004 Chevrolet Malibu2004 Chevrolet Lumina SS2004 Chevrolet Impala SS2004 Chevrolet Express2004 Chevrolet Electric S-10 Concept2004 Chevrolet Corvette Z06 Commemorative Edition2004 Chevrolet Colorado Regular Cab2004 Chevrolet Colorado LS Z71 Extended Cab2004 Chevrolet Colorado LS Z71 Crew Cab2004 Chevrolet Colorado LS Regular Cab2004 Chevrolet Colorado LS Extended Cab2004 Chevrolet Colorado LS Crew Cab2004 Chevrolet Colorado Extended Cab2004 Chevrolet Colorado Cruz2004 Chevrolet Cheyenne Concept2004 Chevrolet Aveo LS 5 Door2004 Chevrolet Aveo LS 4 Door
Note:
1. The list of automotive Makes at the right edge of the screen. The currently selected ODB-ii codes is for the Chevrolet makes.
2. Look up the other OBD II Trouble Codes, please use the search box. Enter the 5 character trouble codes in the search box and submit the search.
3. Don’t assume a particular OBD-II code means the same for other auto manufacturers as there are many makes specific codes in use.
4. If your OBD-II trouble codes are for a different car, select that vehicle series before searching for the diagnostic codes because not all OBD2 codes used by one manufacture are used by the other makes.
5. The information contained on this site is presented for informational purposes only. We are not responsible for any actions you take on your vehicle. If you have any doubt as to repairs on your vehicle, please contact your technician.