Audi P0230 Fuel Pump Primary Circuit

Description

OBD-II Trouble Code Description for P0230 Audi

Fuel Pump Primary Circuit

What does this mean?

OBD2 Code P0230 Audi definition:
The fuel pump is activated by a PCM-controlled relay. Just as the name implies, a “relay” permits the transmittal of higher amperage current to the fuel pump without that current having to travel through the PCM (Powertrain Control Module). For obvious reasons it’s better to not have higher amperage current anywhere near the PCM. Higher amperage current creates more heat but also in the event of a failure, can cause a PCM failure. This principal applies to any relay. The higher amperages are kept under the hood, away from sensitive areas The relay contains basically two sides. The “control” side which is basically a coil and the “switch” side which is a set of electrical contacts. The control side (or coil side) is the low amp side. It’s fed a switched ignition feed (12 volts with key on)and a ground. The ground circuit is activated by the PCM driver when appropriate. When the PCM fuel pump driver activates the relay coil, the coil acts as an electromagnet that pulls the electrical contacts closed which completes the fuel pump circuit. This closed switch allows voltage to flow on the fuel pump activation circuit, activating the pump. Whenever the key is turned on, the PCM grounds the fuel pump circuit for a few seconds, activating the fuel pump and pressurizing the system. The fuel pump won’t be activated again until the PCM sees an RPM signal. The driver in the PCM is monitored for faults. When activated the driver or ground circuit voltage should be low. When deactivated the driver/ground potential voltage should be high or near battery voltage. If the PCM sees a voltage other than what is expected, P0230 Audi may be set.

Symptoms

Possible sumptoms of OBD code P0230 Audi
Symptoms of a P0230 Audi DTC may include: MIL (malfunction indicator lamp) illumination No start condition No fuel pump operation Fuel pump runs all the time with ignition on

Causes

Possible causes of OBD code P0230 Audi
Potential causes of a P0230 Audi code include: Short to ground on control circuit Fuel pump control circuit open Short to battery voltage on control circuit Harness chafing causing one of above conditions Bad relay Bad PCM

Possible Solutions

Command the fuel pump on and off by using a scan tool or simply turning the ignition key on and off without starting the engine. If the fuel pump activates and deactivates, then start the vehicle and measure the current on the control (ground) circuit for a couple of minutes. It should be less than an amp and stay less than an amp. If it doesn’t then replacing the relay is a good idea at this point. If the fuel pump won’t activate and deactivate, then remove the relay and visually check for discoloration due to heat or loose terminals. If okay, install a test light between the control circuit ignition feed and ground driver terminals (If you’re not sure, don’t attempt). The test light should illuminate when the key is on or the fuel pump is commanded on. If it doesn’t, then make sure there is voltage on one side of the coil (switched ignition feed). If voltage is present repair the open or short on the control ground circuit.

The OBD2 Code Information Be Applicable For Audi:

2013 Audi TT ultra quattro Concept,2013 Audi TT RS plus,2013 Audi TTS Roadster competition,2013 Audi TTS Coupe competition,2013 Audi Sport quattro Concept,2013 Audi SQ5 TDI,2013 Audi S8,2013 Audi S7 Sportback,2013 Audi S6 Avant,2013 Audi S6,2013 Audi S4 Avant,2013 Audi S4,2013 Audi RS5 DTM,2013 Audi RS4 Avant,2013 Audi R8 e-tron Concept,2013 Audi R8 V10 plus,2013 Audi R8 V10 Spyder,2013 Audi R8 V10,2013 Audi R8,2013 Audi Q5,2013 Audi Nanuk quattro Concept,2013 Audi A8 L Hybrid,2013 Audi A8 Hybrid,2013 Audi A6 allroad quattro,2013 Audi A6 Black Edition,2013 Audi A4 allroad quattro,2013 Audi A4 Avant,2013 Audi A4,2013 Audi A3 e-tron Concept,2013 Audi A3,2013 Audi A1 quattro,2012 Audi e-bike Worthersee Concept,2012 Audi S5 Sportback,2012 Audi S5 Cabriolet,2012 Audi S5,2012 Audi RS Q3 Concept,2012 Audi RS5,2012 Audi RS3 Sportback,2012 Audi R8 GT Spyder,2012 Audi R8 Exclusive Selection,2012 Audi Q5 Hybrid quattro,2012 Audi Q3 Vail Concept,2012 Audi Q3 Jinlong Yufeng Concept,2012 Audi Q3,2012 Audi Crosslane Coupe Concept,2012 Audi A8 L Security,2012 Audi A6 L e-tron Concept,2012 Audi A6 Hybrid,2012 Audi A6 Avant,2012 Audi A6,2012 Audi A5 Sportback,2012 Audi A5 DTM,2012 Audi A5 Coupe,2012 Audi A5 Cabriolet,2012 Audi A1 amplified,2012 Audi A1 Sportback,2011 Audi Urban Spyder Concept,2011 Audi Urban Concept,2011 Audi TT Roadster,2011 Audi TT Coupe,2011 Audi TTS Roadster,2011 Audi TTS Coupe,2011 Audi S5 Sportback,2011 Audi RS5,2011 Audi R8 Spyder 5.2 FSI quattro,2011 Audi R8 Spyder 4.2 FSI quattro,2011 Audi R8 GT,2011 Audi R18,2011 Audi Q7,2011 Audi A8 L,2011 Audi A8,2011 Audi A7 Sportback,2011 Audi A3 e-tron Concept,2011 Audi A3 Sportback,2011 Audi A3 Concept,2011 Audi A3 Cabriolet,2011 Audi A3,2011 Audi A2 Concept,2011 Audi A1 clubsport quattro Concept,2011 Audi A1,2010 Audi quattro Concept,2010 Audi e-tron Spyder Concept,2010 Audi e-tron Concept,2010 Audi TT RS Roadster,2010 Audi TT RS,2010 Audi TT GT4 Concept,2010 Audi S5 Cabriolet,2010 Audi R8 V10 5.2 FSI quattro,2010 Audi Q7,2010 Audi A8 Hybrid Concept,2010 Audi A5 Sportback,2010 Audi A5 Cabriolet,2010 Audi A4 allroad quattro,2010 Audi A1 e-tron Concept,2009 Audi e-tron Concept,2009 Audi TTS Roadster,2009 Audi TTS Coupe,2009 Audi Sportback Concept,2009 Audi S6 Avant,2009 Audi S6,2009 Audi S4 Avant,2009 Audi S4,2009 Audi S3 Sportback,2009 Audi S3,2009 Audi RS6,2009 Audi R8 GT3,2009 Audi Q7 V12 TDI,2009 Audi Q5 Custom Concept,2009 Audi Q5,2009 Audi A6 allroad quattro,2009 Audi A6 Avant,2009 Audi A6,2009 Audi A4 Avant,2009 Audi A4,2009 Audi A3 Sportback,2009 Audi A3,2008 Audi TT clubsport quattro Concept,2008 Audi TT Roadster 3.2 quattro,2008 Audi TT Coupe,2008 Audi S8,2008 Audi S6,2008 Audi S5,2008 Audi S4 Cabriolet,2008 Audi RS6 Avant UK Version,2008 Audi RS6 Avant,2008 Audi RS4 Cabriolet,2008 Audi RS4,2008 Audi R8 V12 TDI Concept,2008 Audi R8 TDI Le Mans Concept,2008 Audi R8,2008 Audi Q7,2008 Audi A8 L,2008 Audi A8 4.2 TDI quattro,2008 Audi A8L W12 quattro,2008 Audi A8,2008 Audi A6 Avant,2008 Audi A6,2008 Audi A5 3.0 TDI quattro,2008 Audi A5,2008 Audi A4 US Version,2008 Audi A4 TDI Concept e,2008 Audi A4 Cabriolet,2008 Audi A4,2008 Audi A3 US Version,2008 Audi A3 TDI clubsport quattro Concept,2008 Audi A3 Cabriolet,2008 Audi A1 Sportback Concept,2007 Audi metroproject quattro Concept,2007 Audi TT clubsport quattro Concept,2007 Audi TT Roadster 2.0 TFSI,2007 Audi TT Roadster,2007 Audi TT Coupe S-line,2007 Audi TT Coupe,2007 Audi S3,2007 Audi R8,2007 Audi Q7 V12 TDI Concept,2007 Audi Q7 V12 TDI,2007 Audi Cross Coupe quattro Concept,2007 Audi Cross Cabriolet quattro Concept,2006 Audi S8,2006 Audi S6 Avant,2006 Audi S6,2006 Audi S4 Cabriolet,2006 Audi Roadjet Concept,2006 Audi RS 4 Cabriolet,2006 Audi RS 4 Avant,2006 Audi RS4,2006 Audi Q7,2006 Audi A8 Security,2006 Audi A6 allroad quattro,2006 Audi A4 Cabriolet,2006 Audi A3 2.0T,2005 Audi allroad quattro V8 4.2,2005 Audi allroad quattro V6 2.7T,2005 Audi TT quattro sport,2005 Audi TT Roadster 3.2,2005 Audi TT Roadster 1.8T,2005 Audi TT Coupe 3.2,2005 Audi TT Coupe 1.8T,2005 Audi Shooting Brake Concept,2005 Audi S4 Cabriolet,2005 Audi S4 Avant,2005 Audi S4,2005 Audi RS4,2005 Audi Q7 Hybrid Concept,2005 Audi Allroad quattro Concept,2005 Audi A8 L W12,2005 Audi A8 L 4.2,2005 Audi A8 4.2 TDI quattro,2005 Audi A8 4.2,2005 Audi A8 3.2 FSI quattro,2005 Audi A8L 4.2 TDI quattro,2005 Audi A6 Avant,2005 Audi A6 4.2 quattro Sline,2005 Audi A6 3.2,2005 Audi A6 3.0 TDI quattro,2005 Audi A6L,2005 Audi A4 DTM Edition,2005 Audi A4 Cabriolet,2005 Audi A4 Avant 3.2 quattro,2005 Audi A4 3.2 quattro,2005 Audi A4 3.0 TDI quattro,2005 Audi A4 2.0T,2005 Audi A3 2.0 TDI 3-door,2004 Audi S4 Cabriolet,2004 Audi RSQ Concept,2004 Audi RS6 plus,2004 Audi A8 L 6.0 W12 quattro,2004 Audi A8 L 3.0 quattro,2004 Audi A8 4.2 quattro,2004 Audi A8 3.7 quattro,2004 Audi A8 3.0 TDI quattro,2004 Audi A8,2004 Audi A3 Sportback quattro,2004 Audi A3 Sportback S-line,2004 Audi A3 Sportback,2004 Audi A3 3-door,2003 Audi allroad quattro,2003 Audi TT Roadster 3.2 quattro,2003 Audi TT 3.2 DSG quattro,2003 Audi Pikes Peake quattro Concept,2003 Audi Nuvolari quattro Concept,2003 Audi Le Mans quattro Concept,2003 Audi A8 L 4.2 quattro,2003 Audi A8 4.0 TDI quattro,2003 Audi A4,2003 Audi A3 3.2 V6 3-door,2003 Audi A3 3-door,2003 Audi A2,2002 Audi allroad quattro 4.2,2002 Audi allroad quattro,2002 Audi TT Roadster,2002 Audi S6 Avant,2002 Audi S6,2002 Audi S4 Avant,2002 Audi S4,2002 Audi S3,2002 Audi RS6 Sedan,2002 Audi RS6 Avant,2002 Audi RS6,2002 Audi A6,2002 Audi A4 Cabriolet 3.0,2002 Audi A4 Cabriolet 2.4,2002 Audi A4 Cabriolet 1.8 T,2002 Audi A4 Cabriolet,2002 Audi A4 Avant,2002 Audi A4,2002 Audi A3 3-door,2002 Audi A2,2001 Audi TT Coupe,2001 Audi Avantissimo Concept,2001 Audi A8 L 6.0 quattro,2001 Audi A6 Avant,2001 Audi A6,2001 Audi A4 Avant,2001 Audi A4

 

Note:

1. The list of automotive Makes at the right edge of the screen. The currently selected ODB-ii codes is for the Audi makes.

2. Look up the other OBD II Trouble Codes, please use the search box. Enter the 5 character trouble codes in the search box and submit the search.

3. Don’t assume a particular OBD-II code means the same for other auto manufacturers as there are many makes specific codes in use.

4. If your OBD-II trouble codes are for a different car, select that vehicle series before searching for the diagnostic codes because not all OBD2 codes used by one manufacture are used by the other makes.

5. The information contained on this site is presented for informational purposes only. We are not responsible for any actions you take on your vehicle. If you have any doubt as to repairs on your vehicle, please contact your technician.