Description
OBD-II Trouble Code Description for P0403 BMW
Exhaust Gas Recirculation Control Circuit
What does this mean?
OBD2 Code P0403 BMW definition:
The Exhaust Gas Recirculation (EGR) system is controlled by a vacuum solenoid. The solenoid is supplied ignition voltage. The Powertrain Control Module (PCM) controls the vacuum solenoid by grounding the control circuit(ground) or driver. The primary function of the driver is to supply ground for the object that is being controlled. Each driver has a fault circuit that the PCM monitors. When the PCM turns a component on, the control circuit voltage is low, or close to zero. When the component is turned off, the voltage on the control circuit is high, or near battery voltage. The PCM watches for these conditions, and if it doesn’t see the proper voltage at the proper time, this code is set.
Symptoms
Possible sumptoms of OBD code P0403 BMW
Usually a fault in the control circuit, will leave no noticeable symptoms other than the Malfunction Indicator Lamp (MIL) illumination. However, if the EGR control solenoid is stuck open due to debris, etc. the code may be accompanied by misfire under acceleration, rough idle, or engine dying altogether.
Causes
Possible causes of OBD code P0403 BMW
The causes for a P0403 BMW EGR code could be any of the following: Bad EGR solenoid Excessive resistance in control circuit (PCM controlled ground) due to an open, chafing or damage to the harness Poor connection at the EGR solenoid harness (worn or loose pins) Water intrusion at the EGR solenoid harness Blockage in EGR control solenoid holding solenoid open or closed causing excessive resistance Loss of supply voltage to EGR solenoid Bad PCM
Possible Solutions
With the ignition on and engine off, use a scan tool to activate the EGR solenoid. Listen or feel for a clicking, indicating that the solenoid is operating. If the solenoid does operate, you’ll have to check current draw on the ground circuit. It should be less than one amp. If it is then the problem is intermittent. If it isn’t then there is excessive resistance in the circuit and perform the following 1. When it’s activated see if you can blow lightly through it. IF you can’t there may be a blockage causing excessive resistance. Replace EGR solenoid as needed. If there is no blockage, disconnect the EGR solenoid and the PCM connector containing the EGR solenoid control circuit. Using a digital Volt-Ohm meter (DVOM) check resistence between the control circuit and battery ground. It should be infinite. If it isn’t, then there is a short to ground on the control circuit. Repair the short to ground and retest as needed. 2. If the solenoid doesn’t click as it should, disconnect the EGR solenoid connector and connect a test light between the two wires. Using the scan tool, command the EGR solenoid on. The light should light up. If it does, replace the EGR solenoid. If it does not perform the following: a. Check for 12 Volts on the ignition supply voltage to the solenoid. If it isn’t present, inspect the supply circuit for an open, or a short due to chafing or breakage and re-test. b. If it still doesn’t operate: then manually ground the EGR solenoid control circuit. The light should light. If it does, repair open in EGR solenoid control circuit and re-test. If it doesn’t, replace EGR solenoid.
The OBD2 Code Information Be Applicable For BMW:
2013 BMW X6 M50d,2013 BMW X6,2013 BMW X5 eDrive Concept,2013 BMW X5 Security Plus Concept,2013 BMW X5 M50d,2013 BMW X4 Concept,2013 BMW X1,2013 BMW Pininfarina Gran Lusso Coupe,2013 BMW M6 Coupe US-Version,2013 BMW M6 Coupe,2013 BMW M6 Convertible,2013 BMW M5 US-Version,2013 BMW M550d xDrive Touring,2013 BMW M550d xDrive,2013 BMW M4 Coupe Concept,2013 BMW M135i,2013 BMW Active Tourer Outdoor Concept,2013 BMW 7 ActiveHybrid,2013 BMW 750Li,2013 BMW 7-Series,2013 BMW 640i Gran Coupe,2013 BMW 640d xDrive Coupe,2013 BMW 6-Series Gran Coupe UK Version,2013 BMW 6-Series Gran Coupe,2013 BMW 5 ActiveHybrid,2013 BMW 4-Series Coupe Concept,2013 BMW 3 ActiveHybrid,2013 BMW 3-Series Touring,2013 BMW 3-Series Long Wheelbase,2013 BMW 1-Series 3-door,2012 BMW i8 Spyder Concept,2012 BMW i3 Coupe Concept,2012 BMW Zagato Roadster Concept,2012 BMW Zagato Coupe Concept,2012 BMW M5 UK Version,2012 BMW M5,2012 BMW M3 DTM Champion Edition,2012 BMW M3 CRT,2012 BMW M135i Concept,2012 BMW Active Tourer Concept,2012 BMW 650i Convertible,2012 BMW 640d Coupe,2012 BMW 6-Series Coupe,2012 BMW 6-Series Convertible,2012 BMW 3-Series,2012 BMW 1-Series Urban Line,2012 BMW 1-Series Sport Line,2012 BMW 1-Series Coupe,2012 BMW 1-Series Convertible,2012 BMW 1-Series,2011 BMW i8 Concept,2011 BMW i3 Concept,2011 BMW Z4,2011 BMW X5,2011 BMW X3 xDrive35i,2011 BMW X3 xDrive20d,2011 BMW X3,2011 BMW X1 xDrive28i,2011 BMW M5 Concept,2011 BMW M3 Pickup Concept,2011 BMW M3 GTS,2011 BMW M3 Frozen Gray,2011 BMW ConnectedDrive Concept,2011 BMW ActiveE Concept,2011 BMW 750Li,2011 BMW 5-Series Touring,2011 BMW 5-Series Long-Wheelbase,2011 BMW 5-Series,2011 BMW 335is Coupe,2011 BMW 328 Hommage Concept,2011 BMW 3-Series Coupe,2011 BMW 3-Series Convertible,2011 BMW 1-Series M Coupe US Version,2011 BMW 1-Series M Coupe UK Version,2011 BMW 1-Series M Coupe MotoGP Safety Car,2011 BMW 1-Series M Coupe,2010 BMW Z4 UK Version,2010 BMW Z4 GT3,2010 BMW Z4,2010 BMW X6 M,2010 BMW X6 ActiveHybrid,2010 BMW X5 M,2010 BMW X1,2010 BMW Scooter C Concept,2010 BMW M3,2010 BMW Gran Coupe Concept,2010 BMW ActiveE Concept,2010 BMW 7 ActiveHybrid,2010 BMW 760Li,2010 BMW 7-Series High Security,2010 BMW 6-Series Coupe Concept,2010 BMW 5-Series Gran Turismo,2010 BMW 5-Series ActiveHybrid Concept,2010 BMW 320d EfficientDynamics,2010 BMW 135i Coupe,2010 BMW 135i Convertible,2009 BMW X6 UK Version,2009 BMW X6,2009 BMW X5 xDrive35d BluePerformance,2009 BMW X5 Security Plus,2009 BMW X5 Security,2009 BMW X3 Limited Sport Edition,2009 BMW M3 Saloon UK Version,2009 BMW M3 Race Version,2009 BMW M3 Convertible UK Version,2009 BMW M3 Convertible,2009 BMW EfficientDynamics Concept,2009 BMW 750Li,2009 BMW 730d,2009 BMW 7-Series UK Version,2009 BMW 7-Series,2009 BMW 5-Series Gran Turismo Concept,2009 BMW 335d BluePerformance,2009 BMW 3-Series UK Version,2009 BMW 3-Series Touring UK Version,2009 BMW 3-Series Touring,2009 BMW 3-Series,2009 BMW 1-Series Convertible UK Version,2008 BMW X5 M-Package,2008 BMW X1 Concept,2008 BMW M5 Touring,2008 BMW M3 Sedan US-Version,2008 BMW M3 Sedan,2008 BMW M3 Coupe US-Version,2008 BMW M3 Coupe UK Version,2008 BMW M3 Coupe,2008 BMW M1 Concept,2008 BMW M-Zero Concept,2008 BMW GINA Light Visionary Model Concept,2008 BMW EfficientDynamics Concept,2008 BMW Coupe Range,2008 BMW 7-Series ActiveHybrid Concept,2008 BMW 650i Convertible,2008 BMW 635d Coupe,2008 BMW 530i,2008 BMW 5-Series Touring,2008 BMW 5-Series Security,2008 BMW 5-Series,2008 BMW 135i Coupe,2008 BMW 128i Convertible,2008 BMW 1-Series Range,2008 BMW 1-Series Coupe,2008 BMW 1-Series Cabrio,2008 BMW 1-Series 5-door,2008 BMW 1-Series 3-door,2007 BMW X6 Concept,2007 BMW X6 ActiveHybrid Concept,2007 BMW X5 4.8i,2007 BMW X5 3.0d,2007 BMW X3,2007 BMW M6 Convertible Neiman Marcus,2007 BMW M6 Cabrio,2007 BMW M5,2007 BMW M3 Concept,2007 BMW Hydrogen 7,2007 BMW Concept CS,2007 BMW 530Li,2007 BMW 335i Coupe,2007 BMW 335i Convertible,2007 BMW 1-Series tii Concept,2006 BMW Z4 Roadster,2006 BMW Z4 M Roadster,2006 BMW Z4 M Coupe UK version,2006 BMW Z4 M Coupe,2006 BMW Z4 Coupe,2006 BMW Mille Miglia Coupe Concept,2006 BMW Art Car Collection,2006 BMW 7 Series High Security,2006 BMW 760Li,2006 BMW 750i,2006 BMW 750Li with Shadow Line,2006 BMW 750Li,2006 BMW 330i,2006 BMW 325i Touring,2006 BMW 320si E90 WTCC,2006 BMW 320si,2006 BMW 320d Touring,2006 BMW 320d,2005 BMW Z4 Coupe Concept,2005 BMW X5,2005 BMW X3 EfficientDynamics Concept,2005 BMW X3,2005 BMW M6,2005 BMW M5,2005 BMW H2R,2005 BMW 630i,2005 BMW 545i Touring,2005 BMW 530xi Touring,2005 BMW 530xi,2005 BMW 530d Touring,2005 BMW 330i M-Package,2005 BMW 320d Touring,2005 BMW 130i M-Package,2005 BMW 130i,2005 BMW 120i UK Version,2005 BMW 120i,2005 BMW 120d,2004 BMW X5 4.8is,2004 BMW X5 4.4i,2004 BMW X3 3.0i,2004 BMW X3 2.0d,2004 BMW H2R Hydrogen Racecar,2004 BMW Concept M5,2004 BMW 645Ci Convertible,2004 BMW 645Ci,2004 BMW 5 Series,2004 BMW 530i,2004 BMW 530d,2004 BMW 330Ci Coupe,2004 BMW 330Ci Convertible,2004 BMW 330Cd Coupe,2004 BMW 325Ci Coupe,2004 BMW 320Cd Convertible,2004 BMW 318Ci Convertible,2003 BMW Z4 2.5i,2003 BMW Z4,2003 BMW M3 CSL,2003 BMW 760Li E66,2003 BMW 325ti Compact,2003 BMW 3-Series Compact,2002 BMW xActivity Concept,2002 BMW X5 4.6is,2002 BMW CS1 Concept,2002 BMW 7 Series,2002 BMW 760i,2002 BMW 760Li Yachtline Concept,2002 BMW 740d,2002 BMW 730d,2002 BMW 3-Series Touring,2002 BMW 3-Series,2001 BMW Z8
Note:
1. The list of automotive Makes at the right edge of the screen. The currently selected ODB-ii codes is for the BMW makes.
2. Look up the other OBD II Trouble Codes, please use the search box. Enter the 5 character trouble codes in the search box and submit the search.
3. Don’t assume a particular OBD-II code means the same for other auto manufacturers as there are many makes specific codes in use.
4. If your OBD-II trouble codes are for a different car, select that vehicle series before searching for the diagnostic codes because not all OBD2 codes used by one manufacture are used by the other makes.
5. The information contained on this site is presented for informational purposes only. We are not responsible for any actions you take on your vehicle. If you have any doubt as to repairs on your vehicle, please contact your technician.