Description
OBD-II Trouble Code Description for P0403 Chevrolet
Exhaust Gas Recirculation Control Circuit
What does this mean?
OBD2 Code P0403 Chevrolet definition:
The Exhaust Gas Recirculation (EGR) system is controlled by a vacuum solenoid. The solenoid is supplied ignition voltage. The Powertrain Control Module (PCM) controls the vacuum solenoid by grounding the control circuit(ground) or driver. The primary function of the driver is to supply ground for the object that is being controlled. Each driver has a fault circuit that the PCM monitors. When the PCM turns a component on, the control circuit voltage is low, or close to zero. When the component is turned off, the voltage on the control circuit is high, or near battery voltage. The PCM watches for these conditions, and if it doesn’t see the proper voltage at the proper time, this code is set.
Symptoms
Possible sumptoms of OBD code P0403 Chevrolet
Usually a fault in the control circuit, will leave no noticeable symptoms other than the Malfunction Indicator Lamp (MIL) illumination. However, if the EGR control solenoid is stuck open due to debris, etc. the code may be accompanied by misfire under acceleration, rough idle, or engine dying altogether.
Causes
Possible causes of OBD code P0403 Chevrolet
The causes for a P0403 Chevrolet EGR code could be any of the following: Bad EGR solenoid Excessive resistance in control circuit (PCM controlled ground) due to an open, chafing or damage to the harness Poor connection at the EGR solenoid harness (worn or loose pins) Water intrusion at the EGR solenoid harness Blockage in EGR control solenoid holding solenoid open or closed causing excessive resistance Loss of supply voltage to EGR solenoid Bad PCM
Possible Solutions
With the ignition on and engine off, use a scan tool to activate the EGR solenoid. Listen or feel for a clicking, indicating that the solenoid is operating. If the solenoid does operate, you’ll have to check current draw on the ground circuit. It should be less than one amp. If it is then the problem is intermittent. If it isn’t then there is excessive resistance in the circuit and perform the following 1. When it’s activated see if you can blow lightly through it. IF you can’t there may be a blockage causing excessive resistance. Replace EGR solenoid as needed. If there is no blockage, disconnect the EGR solenoid and the PCM connector containing the EGR solenoid control circuit. Using a digital Volt-Ohm meter (DVOM) check resistence between the control circuit and battery ground. It should be infinite. If it isn’t, then there is a short to ground on the control circuit. Repair the short to ground and retest as needed. 2. If the solenoid doesn’t click as it should, disconnect the EGR solenoid connector and connect a test light between the two wires. Using the scan tool, command the EGR solenoid on. The light should light up. If it does, replace the EGR solenoid. If it does not perform the following: a. Check for 12 Volts on the ignition supply voltage to the solenoid. If it isn’t present, inspect the supply circuit for an open, or a short due to chafing or breakage and re-test. b. If it still doesn’t operate: then manually ground the EGR solenoid control circuit. The light should light. If it does, repair open in EGR solenoid control circuit and re-test. If it doesn’t, replace EGR solenoid.
The OBD2 Code Information Be Applicable For Chevrolet
2013 Chevrolet Traverse2013 Chevrolet Trailblazer2013 Chevrolet Spark2013 Chevrolet Sonic RS2013 Chevrolet Onix2013 Chevrolet Malibu ECO2013 Chevrolet Malibu2013 Chevrolet Cruze Station Wagon2013 Chevrolet Corvette 427 Convertible2013 Chevrolet Camaro ZL1 Convertible2013 Chevrolet Camaro Hot Wheels Edition2013 Chevrolet Camaro 1LE2012 Chevrolet Tru 140S Concept2012 Chevrolet Sonic Sedan2012 Chevrolet Sonic2012 Chevrolet Silverado2012 Chevrolet Orlando2012 Chevrolet Cruze Hatchback2012 Chevrolet Corvette Z06 Centennial Edition2012 Chevrolet Corvette Daytona Racecar2012 Chevrolet Colorado2012 Chevrolet Code 130R Concept2012 Chevrolet Captiva2012 Chevrolet Camaro ZL12012 Chevrolet Camaro EU Version2012 Chevrolet Camaro Convertible EU Version2012 Chevrolet Camaro COPO Convertible2012 Chevrolet Camaro COPO2012 Chevrolet Camaro 67 Hot Wheels Concept2012 Chevrolet Camaro 45th Anniversary Edition2012 Chevrolet Aveo Sedan2011 Chevrolet Volt2011 Chevrolet TrailBlazer Concept2011 Chevrolet Silverado HD2011 Chevrolet Sail2011 Chevrolet Miray Concept2011 Chevrolet Cruze2011 Chevrolet Corvette Z06 Carbon Limited Edition2011 Chevrolet Colorado Rally Concept2011 Chevrolet Colorado Concept2011 Chevrolet Caprice Police Patrol Vehicle2011 Chevrolet Camaro SS Convertible Indy 500 Pace Car2011 Chevrolet Camaro Convertible Neiman Marcus2011 Chevrolet Camaro Convertible2011 Chevrolet Aveo2010 Chevrolet Volt MPV5 Concept2010 Chevrolet Spark2010 Chevrolet Equinox2010 Chevrolet Corvette Z06X Concept2010 Chevrolet Corvette Grand Sport2010 Chevrolet Camaro Transformers2010 Chevrolet Camaro SS Indy 500 Pace Car2010 Chevrolet Camaro SSX Concept2010 Chevrolet Camaro SS2010 Chevrolet Camaro Red Flash Concept2010 Chevrolet Camaro2010 Chevrolet Aveo RS Concept2010 Chevrolet Agile2009 Chevrolet Traverse2009 Chevrolet Stingray Concept2009 Chevrolet Cruze WTCC2009 Chevrolet Cruze2009 Chevrolet Corvette ZR12009 Chevrolet Corvette GT12009 Chevrolet Aveo52008 Chevrolet Orlando Concept2008 Chevrolet Matiz2008 Chevrolet Malibu LTZ2008 Chevrolet Malibu LT2008 Chevrolet Lumina SS2008 Chevrolet HHR SS2008 Chevrolet GPiX Concept2008 Chevrolet Equinox Sport2008 Chevrolet Corvette2008 Chevrolet Captiva Sport2008 Chevrolet Camaro LS7 Concept2008 Chevrolet Camaro GS Racecar Concept2008 Chevrolet Camaro Black Concept2008 Chevrolet Aveo2007 Chevrolet Volt Concept2007 Chevrolet Trax Concept2007 Chevrolet Tahoe2007 Chevrolet Suburban LTZ2007 Chevrolet Silverado Regular Cab2007 Chevrolet Silverado Extended Cab2007 Chevrolet Silverado Crew Cab2007 Chevrolet Silverado 3500 HD LTZ Crew Cab2007 Chevrolet Silverado 2500 HD LTZ Extended Cab2007 Chevrolet Jay Lenos Corvette C6RS E852007 Chevrolet HHR Panel2007 Chevrolet Groove Concept2007 Chevrolet Camaro Convertible Concept2007 Chevrolet Beat Concept2007 Chevrolet Avalanche LTZ2007 Chevrolet 34 Coupe E85 Concept2006 Chevrolet WTCC Ultra Concept2006 Chevrolet TrailBlazer SS2006 Chevrolet Silverado Z71 Extended Cab2006 Chevrolet Silverado Intimidator SS2006 Chevrolet Silverado Hydrogen Military Vehicle2006 Chevrolet Sequel Concept2006 Chevrolet Nubira Station Wagon WTCC R2006 Chevrolet Monte Carlo SS2006 Chevrolet Malibu SS2006 Chevrolet Malibu Maxx SS2006 Chevrolet Kodiak C45002006 Chevrolet Impala SS2006 Chevrolet Impala2006 Chevrolet HHR LT2006 Chevrolet Epica2006 Chevrolet Corvette Z06 Daytona 500 Pace Car2006 Chevrolet Corvette Z062006 Chevrolet Cobalt SS2006 Chevrolet Cobalt LT2006 Chevrolet Celta2006 Chevrolet Captiva2006 Chevrolet Camaro Concept2006 Chevrolet Aveo Sedan2005 Chevrolet West Coast Customs HHR2005 Chevrolet Uplander2005 Chevrolet Silverado Hybrid2005 Chevrolet Kodiak2005 Chevrolet Equinox2005 Chevrolet Corvette C6R Race Car2005 Chevrolet Corvette C62005 Chevrolet Corvette2005 Chevrolet Cobalt Sedan2005 Chevrolet Cobalt SS Supercharged Coupe2005 Chevrolet Cobalt SS2005 Chevrolet Cobalt2005 Chevrolet Cavalier Xtreme2005 Chevrolet Astra GSi 2.0 16V2005 Chevrolet Astra 2.0 Flexpower Elite2005 Chevrolet Astra 2.0 Flexpower Elegance2005 Chevrolet Astra 2.0 Flexpower Comfort2004 Chevrolet Tracker Turbo2004 Chevrolet Silverado2004 Chevrolet SOCAL SSR Bonneville Salt Flats2004 Chevrolet S3X Concept2004 Chevrolet Nomad Concept2004 Chevrolet Monte Carlo SS2004 Chevrolet Matiz M3X Concept2004 Chevrolet Malibu Maxx2004 Chevrolet Malibu2004 Chevrolet Lumina SS2004 Chevrolet Impala SS2004 Chevrolet Express2004 Chevrolet Electric S-10 Concept2004 Chevrolet Corvette Z06 Commemorative Edition2004 Chevrolet Colorado Regular Cab2004 Chevrolet Colorado LS Z71 Extended Cab2004 Chevrolet Colorado LS Z71 Crew Cab2004 Chevrolet Colorado LS Regular Cab2004 Chevrolet Colorado LS Extended Cab2004 Chevrolet Colorado LS Crew Cab2004 Chevrolet Colorado Extended Cab2004 Chevrolet Colorado Cruz2004 Chevrolet Cheyenne Concept2004 Chevrolet Aveo LS 5 Door2004 Chevrolet Aveo LS 4 Door
Note:
1. The list of automotive Makes at the right edge of the screen. The currently selected ODB-ii codes is for the Chevrolet makes.
2. Look up the other OBD II Trouble Codes, please use the search box. Enter the 5 character trouble codes in the search box and submit the search.
3. Don’t assume a particular OBD-II code means the same for other auto manufacturers as there are many makes specific codes in use.
4. If your OBD-II trouble codes are for a different car, select that vehicle series before searching for the diagnostic codes because not all OBD2 codes used by one manufacture are used by the other makes.
5. The information contained on this site is presented for informational purposes only. We are not responsible for any actions you take on your vehicle. If you have any doubt as to repairs on your vehicle, please contact your technician.