Description
OBD-II Trouble Code Description for P0216 Mercedes
Injector/Injection Timing Control Circuit
What does this mean?
OBD2 Code P0216 Mercedes definition:
Basically this means the diesel fuel injection pump has a timing failure. This could be that the injection pump timing needs adjusted OR the failure is internal to the injection pump and therefore non-adjustable. NOTE: If your vehicle is a Dodge Ram with Cummins engine then be aware that fuel delivery problems frequently cause this code. Prolonged fuel delivery problems can cause injection pump failure!
Symptoms
Possible sumptoms of OBD code P0216 Mercedes
Symptoms of a P0216 Mercedes DTC may include: P0216 Mercedes DTC Low power Crank, but no start Hard start Displays an intermittent stumble or miss Engine may start and then stall Engine may appear to drive fine but surge at idle
Causes
Possible causes of OBD code P0216 Mercedes
The most frequent cause of this code is a bad injection pump due to poor fuel delivery. Fuel delivery problems could be: A plugged diesel fuel filter An in-tank blockage Air in the fuel due to a cracked in-tank fuel ine above the fuel level Bad transfer (lift) pump Injection pump out of time
Possible Solutions
First, simply check if your injection pump timing is adjustable. If so, check the timing and adjust if necessary. If you think that you may have a fuel delivery problem, then check the lift pump operation. On Dodge Ram with the Cummins engine, the lift pump should produce about 45 oz of diesel in 25 seconds of operation. This can be performed by disconnecting the fuel hose from the injection pump and pumping the fuel into an approved container. Bump the engine over but do not start it. Then the lift pump will operate for 25 seconds. If the fuel is aerated, then check/repair fuel line and recheck. With the fuel hose connected the fuel pressure should be 10psi. If the fuel delivery tests fail, replace the diesel fuel filter and recheck. If it still fails then verify there are no restrictions in the fuel tank Then replace the lift (transfer) pump. IT SHOULD BE NOTED that if this code surfaced after a routine fuel filter replacement or if you have any of the above symptoms after routine fuel filter replacement, then suspect the fuel transfer pump. This occurs because even a weak transfer pump can still provide enough fuel for the engine to run. But when the fuel system’s prime is lost due to fuel filter replacement, it may not restart again without fixing the fuel delivery problem. If you found your injection pump to be bad, the lift pump should be checked for operation to protect the new injection pump. This is because weak or low output from lift pump are common cause of injection pump failure. There are some aftermarket kits that can be purchased to warn the operator when the fuel pressure/volume drops to level that could damage the injection pump.
The OBD2 Code Information Be Applicable For Mercedes-Benz:
2013 Mercedes-Benz SLS AMG GT,2013 Mercedes-Benz SL65 AMG,2013 Mercedes-Benz SL550,2013 Mercedes-Benz SL500,2013 Mercedes-Benz SL-Class,2013 Mercedes-Benz GLK350 4Matic,2013 Mercedes-Benz GLK-Class,2013 Mercedes-Benz GL63 AMG,2013 Mercedes-Benz GL-Class,2013 Mercedes-Benz G63 AMG 6×6 Concept,2013 Mercedes-Benz G63 AMG,2013 Mercedes-Benz G550,2013 Mercedes-Benz G350 Bluetec,2013 Mercedes-Benz G-Class,2013 Mercedes-Benz E300 BlueTEC Hybrid,2013 Mercedes-Benz Citan,2013 Mercedes-Benz CLS Shooting Brake,2013 Mercedes-Benz A-Class AMG Sport,2013 Mercedes-Benz A-Class,2012 Mercedes-Benz SLS AMG Roadster,2012 Mercedes-Benz SLK55 AMG,2012 Mercedes-Benz SLK350,2012 Mercedes-Benz SLK250 CDI,2012 Mercedes-Benz SLK-Class,2012 Mercedes-Benz ML63 AMG,2012 Mercedes-Benz M-Class,2012 Mercedes-Benz E63 AMG Wagon,2012 Mercedes-Benz E63 AMG,2012 Mercedes-Benz CLS63 AMG,2012 Mercedes-Benz CLS550,2012 Mercedes-Benz CLS350 CDI,2012 Mercedes-Benz CLS-Class,2012 Mercedes-Benz C63 AMG,2012 Mercedes-Benz C-Class,2012 Mercedes-Benz B-Class,2011 Mercedes-Benz Vito,2011 Mercedes-Benz Viano,2011 Mercedes-Benz SLS AMG,2011 Mercedes-Benz S63 AMG,2011 Mercedes-Benz S600 Pullman Guard,2011 Mercedes-Benz R-Class,2011 Mercedes-Benz ML 63 AMG,2011 Mercedes-Benz G-Class,2011 Mercedes-Benz F125 Concept,2011 Mercedes-Benz E550 Cabriolet,2011 Mercedes-Benz E350 Cabriolet,2011 Mercedes-Benz E350 4Matic Wagon,2011 Mercedes-Benz E-Class L,2011 Mercedes-Benz E-Class Cabriolet,2011 Mercedes-Benz CL65 AMG,2011 Mercedes-Benz CL63 AMG,2011 Mercedes-Benz CL500,2011 Mercedes-Benz CL-Class,2011 Mercedes-Benz C-Class DR 520,2011 Mercedes-Benz B55 Concept,2011 Mercedes-Benz A-Class E-CELL,2011 Mercedes-Benz A-Class Concept,2010 Mercedes-Benz S65 AMG,2010 Mercedes-Benz S63 AMG,2010 Mercedes-Benz S400 BlueHYBRID,2010 Mercedes-Benz S-Class,2010 Mercedes-Benz ML450 Hybrid,2010 Mercedes-Benz GLK-Class,2010 Mercedes-Benz GL550,2010 Mercedes-Benz E63 AMG Estate,2010 Mercedes-Benz E63 AMG,2010 Mercedes-Benz E550 Coupe,2010 Mercedes-Benz E550,2010 Mercedes-Benz E350 Coupe,2010 Mercedes-Benz E350,2010 Mercedes-Benz E-Class,2010 Mercedes-Benz Biome Concept,2010 Mercedes-Benz B-Class F-Cell,2009 Mercedes-Benz SL65 AMG,2009 Mercedes-Benz SL63 AMG,2009 Mercedes-Benz SL-Class,2009 Mercedes-Benz ML 63 AMG,2009 Mercedes-Benz M-Class,2009 Mercedes-Benz G55 AMG,2009 Mercedes-Benz G-Class,2009 Mercedes-Benz CLS 63 AMG,2009 Mercedes-Benz CLS 280,2009 Mercedes-Benz CLC,2009 Mercedes-Benz B-Class,2009 Mercedes-Benz A-Class,2008 Mercedes-Benz SL,2008 Mercedes-Benz SLR,2008 Mercedes-Benz R-Class,2008 Mercedes-Benz CL65 AMG,2008 Mercedes-Benz C63 AMG,2008 Mercedes-Benz C-Class,2007 Mercedes-Benz S 63 AMG,2007 Mercedes-Benz S 600 Guard,2007 Mercedes-Benz S 500 4MATIC,2007 Mercedes-Benz S65 AMG,2007 Mercedes-Benz S550,2007 Mercedes-Benz R 63 AMG,2007 Mercedes-Benz G-Class,2007 Mercedes-Benz CL 63 AMG,2007 Mercedes-Benz CL 600,2007 Mercedes-Benz CL 500,2007 Mercedes-Benz CLS 63 AMG,2007 Mercedes-Benz CLS 350 CGI,2006 Mercedes-Benz SL 65 AMG,2006 Mercedes-Benz SL 600,2006 Mercedes-Benz SL 55 AMG,2006 Mercedes-Benz SL 500,2006 Mercedes-Benz SL 350,2006 Mercedes-Benz SLK 55 AMG SS,2006 Mercedes-Benz SL-Class,2006 Mercedes-Benz S-Class,2006 Mercedes-Benz R500,2006 Mercedes-Benz ML 63 AMG,2006 Mercedes-Benz ML500,2006 Mercedes-Benz ML350,2006 Mercedes-Benz GL 420 CDI,2006 Mercedes-Benz GL450,2006 Mercedes-Benz GL-Class,2006 Mercedes-Benz E 63 AMG,2006 Mercedes-Benz E-Class,2006 Mercedes-Benz CLK 63 AMG,2006 Mercedes-Benz B200 CDI,2006 Mercedes-Benz B150,2005 Mercedes-Benz SLK350,2005 Mercedes-Benz CLS500,2005 Mercedes-Benz CLK350,2005 Mercedes-Benz AClass
Note:
1. The list of automotive Makes at the right edge of the screen. The currently selected ODB-ii codes is for the Mercedes-Benz makes.
2. Look up the other OBD II Trouble Codes, please use the search box. Enter the 5 character trouble codes in the search box and submit the search.
3. Don’t assume a particular OBD-II code means the same for other auto manufacturers as there are many makes specific codes in use.
4. If your OBD-II trouble codes are for a different car, select that vehicle series before searching for the diagnostic codes because not all OBD2 codes used by one manufacture are used by the other makes.
5. The information contained on this site is presented for informational purposes only. We are not responsible for any actions you take on your vehicle. If you have any doubt as to repairs on your vehicle, please contact your technician.