Description
OBD-II Trouble Code Description for P0403 Mercedes
Exhaust Gas Recirculation Control Circuit
What does this mean?
OBD2 Code P0403 Mercedes definition:
The Exhaust Gas Recirculation (EGR) system is controlled by a vacuum solenoid. The solenoid is supplied ignition voltage. The Powertrain Control Module (PCM) controls the vacuum solenoid by grounding the control circuit(ground) or driver. The primary function of the driver is to supply ground for the object that is being controlled. Each driver has a fault circuit that the PCM monitors. When the PCM turns a component on, the control circuit voltage is low, or close to zero. When the component is turned off, the voltage on the control circuit is high, or near battery voltage. The PCM watches for these conditions, and if it doesn’t see the proper voltage at the proper time, this code is set.
Symptoms
Possible sumptoms of OBD code P0403 Mercedes
Usually a fault in the control circuit, will leave no noticeable symptoms other than the Malfunction Indicator Lamp (MIL) illumination. However, if the EGR control solenoid is stuck open due to debris, etc. the code may be accompanied by misfire under acceleration, rough idle, or engine dying altogether.
Causes
Possible causes of OBD code P0403 Mercedes
The causes for a P0403 Mercedes EGR code could be any of the following: Bad EGR solenoid Excessive resistance in control circuit (PCM controlled ground) due to an open, chafing or damage to the harness Poor connection at the EGR solenoid harness (worn or loose pins) Water intrusion at the EGR solenoid harness Blockage in EGR control solenoid holding solenoid open or closed causing excessive resistance Loss of supply voltage to EGR solenoid Bad PCM
Possible Solutions
With the ignition on and engine off, use a scan tool to activate the EGR solenoid. Listen or feel for a clicking, indicating that the solenoid is operating. If the solenoid does operate, you’ll have to check current draw on the ground circuit. It should be less than one amp. If it is then the problem is intermittent. If it isn’t then there is excessive resistance in the circuit and perform the following 1. When it’s activated see if you can blow lightly through it. IF you can’t there may be a blockage causing excessive resistance. Replace EGR solenoid as needed. If there is no blockage, disconnect the EGR solenoid and the PCM connector containing the EGR solenoid control circuit. Using a digital Volt-Ohm meter (DVOM) check resistence between the control circuit and battery ground. It should be infinite. If it isn’t, then there is a short to ground on the control circuit. Repair the short to ground and retest as needed. 2. If the solenoid doesn’t click as it should, disconnect the EGR solenoid connector and connect a test light between the two wires. Using the scan tool, command the EGR solenoid on. The light should light up. If it does, replace the EGR solenoid. If it does not perform the following: a. Check for 12 Volts on the ignition supply voltage to the solenoid. If it isn’t present, inspect the supply circuit for an open, or a short due to chafing or breakage and re-test. b. If it still doesn’t operate: then manually ground the EGR solenoid control circuit. The light should light. If it does, repair open in EGR solenoid control circuit and re-test. If it doesn’t, replace EGR solenoid.
The OBD2 Code Information Be Applicable For Mercedes-Benz:
2013 Mercedes-Benz SLS AMG GT,2013 Mercedes-Benz SL65 AMG,2013 Mercedes-Benz SL550,2013 Mercedes-Benz SL500,2013 Mercedes-Benz SL-Class,2013 Mercedes-Benz GLK350 4Matic,2013 Mercedes-Benz GLK-Class,2013 Mercedes-Benz GL63 AMG,2013 Mercedes-Benz GL-Class,2013 Mercedes-Benz G63 AMG 6×6 Concept,2013 Mercedes-Benz G63 AMG,2013 Mercedes-Benz G550,2013 Mercedes-Benz G350 Bluetec,2013 Mercedes-Benz G-Class,2013 Mercedes-Benz E300 BlueTEC Hybrid,2013 Mercedes-Benz Citan,2013 Mercedes-Benz CLS Shooting Brake,2013 Mercedes-Benz A-Class AMG Sport,2013 Mercedes-Benz A-Class,2012 Mercedes-Benz SLS AMG Roadster,2012 Mercedes-Benz SLK55 AMG,2012 Mercedes-Benz SLK350,2012 Mercedes-Benz SLK250 CDI,2012 Mercedes-Benz SLK-Class,2012 Mercedes-Benz ML63 AMG,2012 Mercedes-Benz M-Class,2012 Mercedes-Benz E63 AMG Wagon,2012 Mercedes-Benz E63 AMG,2012 Mercedes-Benz CLS63 AMG,2012 Mercedes-Benz CLS550,2012 Mercedes-Benz CLS350 CDI,2012 Mercedes-Benz CLS-Class,2012 Mercedes-Benz C63 AMG,2012 Mercedes-Benz C-Class,2012 Mercedes-Benz B-Class,2011 Mercedes-Benz Vito,2011 Mercedes-Benz Viano,2011 Mercedes-Benz SLS AMG,2011 Mercedes-Benz S63 AMG,2011 Mercedes-Benz S600 Pullman Guard,2011 Mercedes-Benz R-Class,2011 Mercedes-Benz ML 63 AMG,2011 Mercedes-Benz G-Class,2011 Mercedes-Benz F125 Concept,2011 Mercedes-Benz E550 Cabriolet,2011 Mercedes-Benz E350 Cabriolet,2011 Mercedes-Benz E350 4Matic Wagon,2011 Mercedes-Benz E-Class L,2011 Mercedes-Benz E-Class Cabriolet,2011 Mercedes-Benz CL65 AMG,2011 Mercedes-Benz CL63 AMG,2011 Mercedes-Benz CL500,2011 Mercedes-Benz CL-Class,2011 Mercedes-Benz C-Class DR 520,2011 Mercedes-Benz B55 Concept,2011 Mercedes-Benz A-Class E-CELL,2011 Mercedes-Benz A-Class Concept,2010 Mercedes-Benz S65 AMG,2010 Mercedes-Benz S63 AMG,2010 Mercedes-Benz S400 BlueHYBRID,2010 Mercedes-Benz S-Class,2010 Mercedes-Benz ML450 Hybrid,2010 Mercedes-Benz GLK-Class,2010 Mercedes-Benz GL550,2010 Mercedes-Benz E63 AMG Estate,2010 Mercedes-Benz E63 AMG,2010 Mercedes-Benz E550 Coupe,2010 Mercedes-Benz E550,2010 Mercedes-Benz E350 Coupe,2010 Mercedes-Benz E350,2010 Mercedes-Benz E-Class,2010 Mercedes-Benz Biome Concept,2010 Mercedes-Benz B-Class F-Cell,2009 Mercedes-Benz SL65 AMG,2009 Mercedes-Benz SL63 AMG,2009 Mercedes-Benz SL-Class,2009 Mercedes-Benz ML 63 AMG,2009 Mercedes-Benz M-Class,2009 Mercedes-Benz G55 AMG,2009 Mercedes-Benz G-Class,2009 Mercedes-Benz CLS 63 AMG,2009 Mercedes-Benz CLS 280,2009 Mercedes-Benz CLC,2009 Mercedes-Benz B-Class,2009 Mercedes-Benz A-Class,2008 Mercedes-Benz SL,2008 Mercedes-Benz SLR,2008 Mercedes-Benz R-Class,2008 Mercedes-Benz CL65 AMG,2008 Mercedes-Benz C63 AMG,2008 Mercedes-Benz C-Class,2007 Mercedes-Benz S 63 AMG,2007 Mercedes-Benz S 600 Guard,2007 Mercedes-Benz S 500 4MATIC,2007 Mercedes-Benz S65 AMG,2007 Mercedes-Benz S550,2007 Mercedes-Benz R 63 AMG,2007 Mercedes-Benz G-Class,2007 Mercedes-Benz CL 63 AMG,2007 Mercedes-Benz CL 600,2007 Mercedes-Benz CL 500,2007 Mercedes-Benz CLS 63 AMG,2007 Mercedes-Benz CLS 350 CGI,2006 Mercedes-Benz SL 65 AMG,2006 Mercedes-Benz SL 600,2006 Mercedes-Benz SL 55 AMG,2006 Mercedes-Benz SL 500,2006 Mercedes-Benz SL 350,2006 Mercedes-Benz SLK 55 AMG SS,2006 Mercedes-Benz SL-Class,2006 Mercedes-Benz S-Class,2006 Mercedes-Benz R500,2006 Mercedes-Benz ML 63 AMG,2006 Mercedes-Benz ML500,2006 Mercedes-Benz ML350,2006 Mercedes-Benz GL 420 CDI,2006 Mercedes-Benz GL450,2006 Mercedes-Benz GL-Class,2006 Mercedes-Benz E 63 AMG,2006 Mercedes-Benz E-Class,2006 Mercedes-Benz CLK 63 AMG,2006 Mercedes-Benz B200 CDI,2006 Mercedes-Benz B150,2005 Mercedes-Benz SLK350,2005 Mercedes-Benz CLS500,2005 Mercedes-Benz CLK350,2005 Mercedes-Benz AClass
Note:
1. The list of automotive Makes at the right edge of the screen. The currently selected ODB-ii codes is for the Mercedes-Benz makes.
2. Look up the other OBD II Trouble Codes, please use the search box. Enter the 5 character trouble codes in the search box and submit the search.
3. Don’t assume a particular OBD-II code means the same for other auto manufacturers as there are many makes specific codes in use.
4. If your OBD-II trouble codes are for a different car, select that vehicle series before searching for the diagnostic codes because not all OBD2 codes used by one manufacture are used by the other makes.
5. The information contained on this site is presented for informational purposes only. We are not responsible for any actions you take on your vehicle. If you have any doubt as to repairs on your vehicle, please contact your technician.